Skip to main content

Did flammable cargo doom Flight 370?

By Sylvia Adcock
updated 3:13 PM EDT, Thu April 24, 2014
The inside of a lithium-ion battery used in a Prius plug-in hyrbrid car is on display.
The inside of a lithium-ion battery used in a Prius plug-in hyrbrid car is on display. "Li-ion" batteries are used extensively in cell phones and laptops.
STORY HIGHLIGHTS
  • Sylvia Adcock: Investigators need to look closely at Flight 370's cargo manifest
  • Adcock: Malaysian officials said jet was carrying 440 pounds of lithium ion batteries
  • Adcock: Lithium ion batteries are flammable, can burn in a way that's difficult to extinguish
  • Checking this is at least as important as investigating pilot's flight simulator, she says

Editor's note: Sylvia Adcock covered aviation safety and security for Newsday from 1996 until 2005. She is editor of NC State magazine, the alumni magazine of North Carolina State University in Raleigh.

(CNN) -- With no wreckage or flight recorders from Flight 370 to guide them, investigators in Malaysia are poring over information about the backgrounds of the pilots and passengers, radar data, and the transmissions from the cockpit. They also need to pay close attention to another important clue: the cargo manifest.

The list of what ends up in the cargo hold of a passenger airplane goes beyond checked luggage. Freight shippers use passenger carriers as well as cargo lines to deliver goods and raw materials. Knowing what was in the cargo hold -- or at least what the official list says was in it -- is important in any accident investigation.

Sylvia Adcock
Sylvia Adcock

It was never more important than it was in the case of the 1996 crash of ValuJet Flight 592.

Opinion: Flight's resting place is best clue

The ValuJet plane, a DC-9, crashed into the Florida Everglades shortly after takeoff from Miami. Investigators found the pilots were unable to control the plane after a fire raced through the cargo hold, disabling some of the plane's systems. The source of the fire was traced to a shipment of oxygen canisters that had been mistakenly labeled and improperly packed.

The accident led to a push by the National Transportation Safety Board to put smoke detectors and fire-suppression systems in the cargo bays of all passenger aircraft. The Federal Aviation Administration responded and today, halon fire-suppression systems tucked into the cargo holds are an important safety feature on passenger planes.

So far, so good. Since then, a new type of cargo has emerged: lithium batteries. There are two types of lithium batteries. One is the rechargeable batteries like those in your phone and laptop, also called lithium ion batteries. A second type, nonrechargeable batteries, also called lithium metal batteries, are used in everything from toys to medical devices.

A policewoman watches a couple whose son was on board the missing Malaysia Airlines Flight 370 cry outside the airline's office building in Beijing after officials refused to meet with them on Wednesday, June 11. The jet has been missing since March 8. A policewoman watches a couple whose son was on board the missing Malaysia Airlines Flight 370 cry outside the airline's office building in Beijing after officials refused to meet with them on Wednesday, June 11. The jet has been missing since March 8.
The search for Malaysia Airlines Flight 370
HIDE CAPTION
<<
<
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
>
>>
Photos: The search for Malaysia Airlines Flight 370 Photos: The search for Malaysia Airlines Flight 370
Listening tools help 'view' ocean floor
Working to pinpoint missing plane

Lithium metal batteries deliver extremely high densities of energy, and if they are mishandled they can catch fire, a fire that can't be extinguished with halon, the most common kind of fire-suppression systems in passenger aircraft. That's one reason the FAA banned shipments of nonrechargeable lithium metal batteries on passenger planes in 2004. But that ban only applies in the United States; international authorities are still considering whether to enact such a rule. Cargo and passenger aircraft are free to carry lithium ion batteries, although they are subject to labeling and packing regulations.

So what was on board Flight 370? Malaysian officials, after saying the cargo manifest would "be released in due course," later got a little more specific and said the Boeing 777 was carrying 440 pounds of lithium ion batteries. What else? Nothing that would cause a problem, the Malaysians assure us. An Australian news media report said the Malaysian government refused to release the manifest to the Australian government, which would find such information helpful as it tries to map out a search.

Let's assume little more than luggage and lithium ion batteries were in the plane's cargo hold. Although lithium ion fires are easier to suppress than lithium metal battery fires, both are susceptible to what's called "thermal runaway" when ignited. That's when one cell ignites the next cell, creating a fire that's more difficult to control with traditional fire suppression methods.

It's worth noting that lithium ion batteries were the main suspect in the crash of a UPS Boeing 747 in Dubai in 2010, killing both pilots as they tried to make an emergency landing. Investigators in the United Arab Emirates studied the cargo records and found that shipments of lithium ion batteries that should have been declared hazardous cargo were not. The reinforced cargo liner was no match for the fire that quickly destroyed the aircraft's control systems and filled the cockpit with smoke, incapacitating the pilots.

Presumably, the Malaysian government is paying close attention to anything on board the aircraft that might have caused a catastrophic fire. They need to be looking beyond the list of transported items, talking to freight shippers who might have had anything on board that was mislabeled, damaged or not handled correctly in transit. That's just as important as talking to the relatives of the pilots and investigating the flight simulator one had in his home -- which, by the way, is not a crime and in the case of a pilot, often only shows a passion for the job.

Follow @CNNOpinion on Twitter.

Join us at Facebook/CNNOpinion.

The opinions expressed in this commentary are solely those of Sylvia Adcock.

ADVERTISEMENT
Part of complete coverage on
updated 4:06 PM EDT, Tue October 21, 2014
Timothy Stanley says Lewinsky is shamelessly playing the victim in her affair with Bill Clinton, humiliating Hillary Clinton again and aiding her critics
updated 9:02 PM EDT, Mon October 20, 2014
Imagine being rescued from modern slavery, only to be charged with a crime, writes John Sutter
updated 12:00 PM EDT, Tue October 21, 2014
Tidal flooding used to be a relatively rare occurrence along the East Coast. Not anymore, write Melanie Fitzpatrick and Erika Spanger-Siegfried.
updated 7:35 AM EDT, Tue October 21, 2014
Carol Costello says activists, writers, politicians have begun discussing their abortions. But will that new approach make a difference on an old battleground?
updated 9:12 AM EDT, Tue October 21, 2014
Sigrid Fry-Revere says the National Organ Transplant Act has caused more Americans to die waiting for an organ than died in both World Wars, Korea, Vietnam, Afghanistan and Iraq
updated 2:51 PM EDT, Tue October 21, 2014
Crystal Wright says racist remarks like those made by black Republican actress Stacey Dash do nothing to get blacks to join the GOP
updated 6:07 PM EDT, Tue October 21, 2014
Mel Robbins says by telling her story, Monica Lewinsky offers a lesson in confronting humiliating mistakes while keeping her head held high
updated 9:29 AM EDT, Mon October 20, 2014
Cornell Belcher says the story of the "tea party wave" in 2010 was bogus; it was an election determined by ebbing Democratic turnout
updated 4:12 PM EDT, Mon October 20, 2014
Les Abend says pilots want protocols, preparation and checklists for all contingencies; at the moment, controlling a deadly disease is out of their comfort zone
updated 11:36 PM EDT, Sun October 19, 2014
David Weinberger says an online controversy that snowballed from a misogynist attack by gamers into a culture war is a preview of the way news is handled in a world of hashtag-fueled scandal
updated 8:23 AM EDT, Mon October 20, 2014
Julian Zelizer says Paul Krugman makes some good points in his defense of President Obama but is premature in calling him one of the most successful presidents.
updated 10:21 PM EDT, Sun October 19, 2014
Conservatives can't bash and slash government and then suddenly act surprised if government isn't there when we need it, writes Sally Kohn
updated 8:05 AM EDT, Wed October 22, 2014
ISIS is looking to take over a good chunk of the Middle East -- if not the entire Muslim world, write Peter Bergen and Emily Schneider.
updated 9:00 AM EDT, Mon October 20, 2014
The world's response to Ebola is its own sort of tragedy, writes John Sutter
updated 4:33 PM EDT, Fri October 17, 2014
Hidden away in Russian orphanages are thousands of children with disabilities who aren't orphans, whose harmful treatment has long been hidden from public view, writes Andrea Mazzarino
updated 1:22 PM EDT, Sat October 18, 2014
When you hear "trick or treat" this year, think "nudge," writes John Bare
updated 12:42 AM EDT, Sat October 18, 2014
The more than 200 kidnapped Nigerian schoolgirls have become pawns in a larger drama, writes Richard Joseph.
updated 9:45 AM EDT, Fri October 17, 2014
Peggy Drexler said Amal Alamuddin was accused of buying into the patriarchy when she changed her name to Clooney. But that was her choice.
updated 4:43 PM EDT, Thu October 16, 2014
Ford Vox says the CDC's Thomas Frieden is a good man with a stellar resume who has shown he lacks the unique talents and vision needed to confront the Ebola crisis
updated 4:58 AM EDT, Sat October 18, 2014
How can such a numerically small force as ISIS take control of vast swathes of Syria and Iraq?
updated 9:42 AM EDT, Fri October 17, 2014
How big a threat do foreign fighters in Syria and Iraq pose to the West? It's a question that has been much on the mind of policymakers and commentators.
updated 8:21 AM EDT, Fri October 17, 2014
More than a quarter-million American women served honorably in the Iraq and Afghanistan wars. Now they are home, we have an obligation to help them transition back to civilian life.
updated 4:27 PM EDT, Thu October 16, 2014
Paul Begala says Rick Scott's deeply weird refusal to begin a debate because rival Charlie Crist had a fan under his podium spells disaster for the Florida governor--delighting Crist
updated 12:07 AM EDT, Thu October 16, 2014
The longer we wait to engage on Ebola, the more limited our options will become, says Marco Rubio.
updated 7:53 AM EDT, Wed October 15, 2014
Democratic candidates who run from President Obama in red states where he is unpopular are making a big mistake, says Donna Brazile
updated 12:29 AM EDT, Thu October 16, 2014
At some 7 billion people, the world can sometimes seem like a crowded place. But if the latest estimates are to be believed, then in less than a century it is going to feel even more so -- about 50% more crowded, says Evan Fraser
updated 12:53 PM EDT, Mon October 20, 2014
Paul Callan says the Ebola situation is pointing up the need for better leadership
updated 6:45 PM EDT, Wed October 15, 2014
Nurses are the unsung heroes of the Ebola outbreak. Yet, there are troubling signs we're failing them, says John Sutter
updated 1:00 PM EDT, Wed October 15, 2014
Dean Obeidallah says it's a mistake to give up a business name you've invested energy in, just because of a new terrorist group
updated 7:01 PM EDT, Wed October 15, 2014
Fear of Ebola is contagious, writes Mel Robbins; but it's time to put the disease in perspective
updated 1:44 PM EDT, Tue October 14, 2014
Oliver Kershaw says that if Big Tobacco is given monopoly of e-cigarette products, public health will suffer.
updated 9:35 AM EDT, Sat October 18, 2014
Stop thinking your job will make you happy.
updated 10:08 PM EDT, Tue October 14, 2014
Ruben Navarrette says it's time to deal with another scandal involving the Secret Service — one that leads directly into the White House.
updated 7:25 AM EDT, Tue October 14, 2014
Americans who choose to fight for militant groups or support them are young and likely to be active in jihadist social media, says Peter Bergen
updated 9:03 AM EDT, Mon October 13, 2014
Stephanie Coontz says 11 years ago only one state allowed same sex marriage. Soon, some 60% of Americans will live where gays can marry. How did attitudes change so quickly?
updated 4:04 PM EDT, Tue October 14, 2014
Legalizing assisted suicide seems acceptable when focusing on individuals. But such laws would put many at risk of immense harm, writes Marilyn Golden.
updated 9:07 AM EDT, Mon October 13, 2014
Julian Zelizer says the issues are huge, but both parties are wrestling with problems that alienate voters
updated 6:50 PM EDT, Mon October 13, 2014
Mel Robbins says the town's school chief was right to cancel the season, but that's just the beginning of what needs to be done
updated 11:43 AM EDT, Sat October 11, 2014
He didn't discover that the world was round, David Perry writes. So what did he do?
ADVERTISEMENT
ADVERTISEMENT
ADVERTISEMENT
ADVERTISEMENT