Skip to main content

Did flammable cargo doom Flight 370?

By Sylvia Adcock
updated 3:13 PM EDT, Thu April 24, 2014
The inside of a lithium-ion battery used in a Prius plug-in hyrbrid car is on display.
The inside of a lithium-ion battery used in a Prius plug-in hyrbrid car is on display. "Li-ion" batteries are used extensively in cell phones and laptops.
STORY HIGHLIGHTS
  • Sylvia Adcock: Investigators need to look closely at Flight 370's cargo manifest
  • Adcock: Malaysian officials said jet was carrying 440 pounds of lithium ion batteries
  • Adcock: Lithium ion batteries are flammable, can burn in a way that's difficult to extinguish
  • Checking this is at least as important as investigating pilot's flight simulator, she says

Editor's note: Sylvia Adcock covered aviation safety and security for Newsday from 1996 until 2005. She is editor of NC State magazine, the alumni magazine of North Carolina State University in Raleigh.

(CNN) -- With no wreckage or flight recorders from Flight 370 to guide them, investigators in Malaysia are poring over information about the backgrounds of the pilots and passengers, radar data, and the transmissions from the cockpit. They also need to pay close attention to another important clue: the cargo manifest.

The list of what ends up in the cargo hold of a passenger airplane goes beyond checked luggage. Freight shippers use passenger carriers as well as cargo lines to deliver goods and raw materials. Knowing what was in the cargo hold -- or at least what the official list says was in it -- is important in any accident investigation.

Sylvia Adcock
Sylvia Adcock

It was never more important than it was in the case of the 1996 crash of ValuJet Flight 592.

Opinion: Flight's resting place is best clue

The ValuJet plane, a DC-9, crashed into the Florida Everglades shortly after takeoff from Miami. Investigators found the pilots were unable to control the plane after a fire raced through the cargo hold, disabling some of the plane's systems. The source of the fire was traced to a shipment of oxygen canisters that had been mistakenly labeled and improperly packed.

The accident led to a push by the National Transportation Safety Board to put smoke detectors and fire-suppression systems in the cargo bays of all passenger aircraft. The Federal Aviation Administration responded and today, halon fire-suppression systems tucked into the cargo holds are an important safety feature on passenger planes.

So far, so good. Since then, a new type of cargo has emerged: lithium batteries. There are two types of lithium batteries. One is the rechargeable batteries like those in your phone and laptop, also called lithium ion batteries. A second type, nonrechargeable batteries, also called lithium metal batteries, are used in everything from toys to medical devices.

On June 26, the Joint Agency Coordination Center released a map showing the new search area for flight MH370 in the southern Indian Ocean. On June 26, the Joint Agency Coordination Center released a map showing the new search area for flight MH370 in the southern Indian Ocean.
The search for Malaysia Airlines Flight 370
HIDE CAPTION
<<
<
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
>
>>
Photos: The search for Malaysia Airlines Flight 370 Photos: The search for Malaysia Airlines Flight 370
Listening tools help 'view' ocean floor
Working to pinpoint missing plane

Lithium metal batteries deliver extremely high densities of energy, and if they are mishandled they can catch fire, a fire that can't be extinguished with halon, the most common kind of fire-suppression systems in passenger aircraft. That's one reason the FAA banned shipments of nonrechargeable lithium metal batteries on passenger planes in 2004. But that ban only applies in the United States; international authorities are still considering whether to enact such a rule. Cargo and passenger aircraft are free to carry lithium ion batteries, although they are subject to labeling and packing regulations.

So what was on board Flight 370? Malaysian officials, after saying the cargo manifest would "be released in due course," later got a little more specific and said the Boeing 777 was carrying 440 pounds of lithium ion batteries. What else? Nothing that would cause a problem, the Malaysians assure us. An Australian news media report said the Malaysian government refused to release the manifest to the Australian government, which would find such information helpful as it tries to map out a search.

Let's assume little more than luggage and lithium ion batteries were in the plane's cargo hold. Although lithium ion fires are easier to suppress than lithium metal battery fires, both are susceptible to what's called "thermal runaway" when ignited. That's when one cell ignites the next cell, creating a fire that's more difficult to control with traditional fire suppression methods.

It's worth noting that lithium ion batteries were the main suspect in the crash of a UPS Boeing 747 in Dubai in 2010, killing both pilots as they tried to make an emergency landing. Investigators in the United Arab Emirates studied the cargo records and found that shipments of lithium ion batteries that should have been declared hazardous cargo were not. The reinforced cargo liner was no match for the fire that quickly destroyed the aircraft's control systems and filled the cockpit with smoke, incapacitating the pilots.

Presumably, the Malaysian government is paying close attention to anything on board the aircraft that might have caused a catastrophic fire. They need to be looking beyond the list of transported items, talking to freight shippers who might have had anything on board that was mislabeled, damaged or not handled correctly in transit. That's just as important as talking to the relatives of the pilots and investigating the flight simulator one had in his home -- which, by the way, is not a crime and in the case of a pilot, often only shows a passion for the job.

Follow @CNNOpinion on Twitter.

Join us at Facebook/CNNOpinion.

The opinions expressed in this commentary are solely those of Sylvia Adcock.

ADVERTISEMENT
Part of complete coverage on
updated 12:26 PM EDT, Wed August 27, 2014
The death of Douglas McAuthur McCain, the first American killed fighting for ISIS, highlights the pull of Syria's war for Western jihadists, writes Peter Bergen.
updated 6:42 PM EDT, Tue August 26, 2014
Former ambassador to Syria Robert Ford says the West should be helping moderates in the Syrian armed opposition end the al-Assad regime and form a government to focus on driving ISIS out
updated 9:21 AM EDT, Wed August 27, 2014
Ruben Navarrette says a great country does not deport thousands of vulnerable, unaccompanied minors who fled in fear for their lives
updated 9:19 AM EDT, Wed August 27, 2014
Robert McIntyre says Congress is the culprit for letting Burger King pay lower taxes after merging with Tim Hortons.
updated 7:35 PM EDT, Tue August 26, 2014
Wesley Clark says the U.S. can offer support to its Islamic friends in the region most threatened by ISIS, but it can't fight their war
updated 7:26 AM EDT, Wed August 27, 2014
Jeff Yang says the tech sector's diversity numbers are embarrassing and the big players need to do more.
updated 4:53 PM EDT, Tue August 26, 2014
America's painful struggle with racism has often brought great satisfaction to the country's rivals, critics, and foes. The killing of Michael Brown and its tumultuous aftermath has been a bonanza.
updated 4:19 PM EDT, Tue August 26, 2014
Ed Bark says in this Emmy year, broadcasters CBS, ABC and PBS can all say they matched or exceeded HBO. These days that's no small feat
updated 3:19 PM EDT, Tue August 26, 2014
Rick Martin says the death of Robin Williams brought back memories of his own battle facing down depression as a young man
updated 11:58 AM EDT, Tue August 26, 2014
David Perry asks: What's the best way for police officers to handle people with psychiatric disabilities?
updated 3:50 PM EDT, Mon August 25, 2014
Julian Zelizer says it's not crazy to think Mitt Romney would be able to end up at the top of the GOP ticket in 2016
updated 4:52 PM EDT, Mon August 25, 2014
Roxanne Jones and her girlfriends would cheer from the sidelines for the boys playing Little League. But they really wanted to play. Now Mo'ne Davis shows the world that girls really can throw.
updated 12:29 PM EDT, Mon August 25, 2014
Peter Bergen and Emily Schneider say a YouTube video apparently posted by ISIS seems to show that the group has a surveillance drone, highlighting a new reality: Terrorist groups have technology once only used by states
updated 5:04 PM EDT, Mon August 25, 2014
Kimberly Norwood is a black mom who lives in an affluent neighborhood not far from Ferguson, but she has the same fears for her children as people in that troubled town do
updated 5:45 PM EDT, Fri August 22, 2014
It apparently has worked for France, say Peter Bergen and Emily Schneider, but carries uncomfortable risks. When it comes to kidnappings, nations face grim options.
updated 1:27 PM EDT, Tue August 26, 2014
John Bare says the Ice Bucket Challenge signals a new kind of activism and peer-to-peer fund-raising.
updated 8:31 AM EDT, Fri August 22, 2014
James Dawes says calling ISIS evil over and over again could very well make it harder to stop them.
updated 9:05 PM EDT, Sat August 23, 2014
As the inquiry into the shooting of Michael Brown continues, critics question the prosecutor's impartiality.
updated 6:47 PM EDT, Fri August 22, 2014
Newt Gingrich says it's troubling that a vicious group like ISIS can recruit so many young men from Britain.
updated 10:50 AM EDT, Thu August 21, 2014
David Weinberger says Twitter and other social networks have been vested with a responsibility, and a trust, they did not ask for.
updated 7:03 AM EDT, Fri August 22, 2014
John Inazu says the slogan "We are Ferguson" is meant to express empathy and solidarity. It's not true: Not all of us live in those circumstances. But we all made them.
updated 8:23 AM EDT, Fri August 22, 2014
Retired Lt. Gen. Mark Hertling says he learned that the territory ISIS wants to control is amazingly complex.
updated 3:51 PM EDT, Wed August 20, 2014
Cerue Garlo says Liberia is desperate for help amid a Ebola outbreak that has touched every aspect of life.
updated 1:42 PM EDT, Thu August 21, 2014
Eric Liu says Republicans who want to restrict voting may win now, but the party will suffer in the long term.
updated 11:38 AM EDT, Thu August 21, 2014
Jay Parini: Jesus, Pope and now researchers agree: Wealth decreases our ability to sympathize with the poor.
updated 8:00 AM EDT, Thu August 21, 2014
Judy Melinek offers a medical examiner's perspective on what happens when police kill people like Michael Brown.
updated 6:03 PM EDT, Tue August 19, 2014
It used to be billy clubs, fire hoses and snarling German shepherds. Now it's armored personnel carriers and flash-bang grenades, writes Kara Dansky.
updated 1:27 PM EDT, Wed August 20, 2014
Maria Haberfeld: People who are unfamiliar with police work can reasonably ask, why was an unarmed man shot so many times, and why was deadly force used at all?
ADVERTISEMENT
ADVERTISEMENT
ADVERTISEMENT
ADVERTISEMENT