Skip to main content

Did flammable cargo doom Flight 370?

By Sylvia Adcock
updated 3:13 PM EDT, Thu April 24, 2014
The inside of a lithium-ion battery used in a Prius plug-in hyrbrid car is on display.
The inside of a lithium-ion battery used in a Prius plug-in hyrbrid car is on display. "Li-ion" batteries are used extensively in cell phones and laptops.
STORY HIGHLIGHTS
  • Sylvia Adcock: Investigators need to look closely at Flight 370's cargo manifest
  • Adcock: Malaysian officials said jet was carrying 440 pounds of lithium ion batteries
  • Adcock: Lithium ion batteries are flammable, can burn in a way that's difficult to extinguish
  • Checking this is at least as important as investigating pilot's flight simulator, she says

Editor's note: Sylvia Adcock covered aviation safety and security for Newsday from 1996 until 2005. She is editor of NC State magazine, the alumni magazine of North Carolina State University in Raleigh.

(CNN) -- With no wreckage or flight recorders from Flight 370 to guide them, investigators in Malaysia are poring over information about the backgrounds of the pilots and passengers, radar data, and the transmissions from the cockpit. They also need to pay close attention to another important clue: the cargo manifest.

The list of what ends up in the cargo hold of a passenger airplane goes beyond checked luggage. Freight shippers use passenger carriers as well as cargo lines to deliver goods and raw materials. Knowing what was in the cargo hold -- or at least what the official list says was in it -- is important in any accident investigation.

Sylvia Adcock
Sylvia Adcock

It was never more important than it was in the case of the 1996 crash of ValuJet Flight 592.

Opinion: Flight's resting place is best clue

The ValuJet plane, a DC-9, crashed into the Florida Everglades shortly after takeoff from Miami. Investigators found the pilots were unable to control the plane after a fire raced through the cargo hold, disabling some of the plane's systems. The source of the fire was traced to a shipment of oxygen canisters that had been mistakenly labeled and improperly packed.

The accident led to a push by the National Transportation Safety Board to put smoke detectors and fire-suppression systems in the cargo bays of all passenger aircraft. The Federal Aviation Administration responded and today, halon fire-suppression systems tucked into the cargo holds are an important safety feature on passenger planes.

So far, so good. Since then, a new type of cargo has emerged: lithium batteries. There are two types of lithium batteries. One is the rechargeable batteries like those in your phone and laptop, also called lithium ion batteries. A second type, nonrechargeable batteries, also called lithium metal batteries, are used in everything from toys to medical devices.

A policewoman watches a couple whose son was on board the missing Malaysia Airlines Flight 370 cry outside the airline's office building in Beijing after officials refused to meet with them on Wednesday, June 11. The jet has been missing since March 8. A policewoman watches a couple whose son was on board the missing Malaysia Airlines Flight 370 cry outside the airline's office building in Beijing after officials refused to meet with them on Wednesday, June 11. The jet has been missing since March 8.
The search for Malaysia Airlines Flight 370
HIDE CAPTION
<<
<
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
>
>>
Photos: The search for Malaysia Airlines Flight 370 Photos: The search for Malaysia Airlines Flight 370
Listening tools help 'view' ocean floor
Working to pinpoint missing plane

Lithium metal batteries deliver extremely high densities of energy, and if they are mishandled they can catch fire, a fire that can't be extinguished with halon, the most common kind of fire-suppression systems in passenger aircraft. That's one reason the FAA banned shipments of nonrechargeable lithium metal batteries on passenger planes in 2004. But that ban only applies in the United States; international authorities are still considering whether to enact such a rule. Cargo and passenger aircraft are free to carry lithium ion batteries, although they are subject to labeling and packing regulations.

So what was on board Flight 370? Malaysian officials, after saying the cargo manifest would "be released in due course," later got a little more specific and said the Boeing 777 was carrying 440 pounds of lithium ion batteries. What else? Nothing that would cause a problem, the Malaysians assure us. An Australian news media report said the Malaysian government refused to release the manifest to the Australian government, which would find such information helpful as it tries to map out a search.

Let's assume little more than luggage and lithium ion batteries were in the plane's cargo hold. Although lithium ion fires are easier to suppress than lithium metal battery fires, both are susceptible to what's called "thermal runaway" when ignited. That's when one cell ignites the next cell, creating a fire that's more difficult to control with traditional fire suppression methods.

It's worth noting that lithium ion batteries were the main suspect in the crash of a UPS Boeing 747 in Dubai in 2010, killing both pilots as they tried to make an emergency landing. Investigators in the United Arab Emirates studied the cargo records and found that shipments of lithium ion batteries that should have been declared hazardous cargo were not. The reinforced cargo liner was no match for the fire that quickly destroyed the aircraft's control systems and filled the cockpit with smoke, incapacitating the pilots.

Presumably, the Malaysian government is paying close attention to anything on board the aircraft that might have caused a catastrophic fire. They need to be looking beyond the list of transported items, talking to freight shippers who might have had anything on board that was mislabeled, damaged or not handled correctly in transit. That's just as important as talking to the relatives of the pilots and investigating the flight simulator one had in his home -- which, by the way, is not a crime and in the case of a pilot, often only shows a passion for the job.

Follow @CNNOpinion on Twitter.

Join us at Facebook/CNNOpinion.

The opinions expressed in this commentary are solely those of Sylvia Adcock.

ADVERTISEMENT
Part of complete coverage on
updated 4:34 PM EST, Fri December 19, 2014
President Obama has been flexing his executive muscles lately despite Democrat's losses, writes Gloria Borger
updated 2:51 PM EST, Thu December 18, 2014
Jeff Yang says the film industry's surrender will have lasting implications.
updated 4:13 PM EST, Thu December 18, 2014
Newt Gingrich: No one should underestimate the historic importance of the collapse of American defenses in the Sony Pictures attack.
updated 7:55 AM EST, Wed December 10, 2014
Dean Obeidallah asks how the genuine Stephen Colbert will do, compared to "Stephen Colbert"
updated 12:34 PM EST, Thu December 18, 2014
Some GOP politicians want drug tests for welfare recipients; Eric Liu says bailed-out execs should get equal treatment
updated 8:42 AM EST, Thu December 18, 2014
Louis Perez: Obama introduced a long-absent element of lucidity into U.S. policy on Cuba.
updated 12:40 PM EST, Tue December 16, 2014
The slaughter of more than 130 children by the Pakistani Taliban may prove as pivotal to Pakistan's security policy as the 9/11 attacks were for the U.S., says Peter Bergen.
updated 11:00 AM EST, Wed December 17, 2014
The Internet is an online extension of our own neighborhoods. It's time for us to take their protection just as seriously, says Arun Vishwanath.
updated 4:54 PM EST, Tue December 16, 2014
Gayle Lemmon says we must speak out for the right of children to education -- and peace
updated 5:23 AM EST, Wed December 17, 2014
Russia's economic woes just seem to be getting worse. How will President Vladimir Putin respond? Frida Ghitis gives her take.
updated 1:39 AM EST, Wed December 17, 2014
Australia has generally seen itself as detached from the threat of terrorism. The hostage incident this week may change that, writes Max Barry.
updated 3:20 PM EST, Fri December 12, 2014
Thomas Maier says the trove of letters the Kennedy family has tried to guard from public view gives insight into the Kennedy legacy and the history of era.
updated 9:56 AM EST, Mon December 15, 2014
Will Congress reform the CIA? It's probably best not to expect much from Washington. This is not the 1970s, and the chances for substantive reform are not good.
updated 4:01 PM EST, Mon December 15, 2014
From superstorms to droughts, not a week goes by without a major disruption somewhere in the U.S. But with the right planning, natural disasters don't have to be devastating.
updated 9:53 AM EST, Mon December 15, 2014
Would you rather be sexy or smart? Carol Costello says she hates this dumb question.
updated 5:53 PM EST, Sun December 14, 2014
A story about Pope Francis allegedly saying animals can go to heaven went viral late last week. The problem is that it wasn't true. Heidi Schlumpf looks at the discussion.
updated 10:50 AM EST, Sun December 14, 2014
Democratic leaders should wake up to the reality that the party's path to electoral power runs through the streets, where part of the party's base has been marching for months, says Errol Louis
updated 4:23 PM EST, Sat December 13, 2014
David Gergen: John Brennan deserves a national salute for his efforts to put the report about the CIA in perspective
updated 9:26 AM EST, Fri December 12, 2014
Anwar Sanders says that in some ways, cops and protesters are on the same side
updated 9:39 AM EST, Thu December 11, 2014
A view by Samir Naji, a Yemeni who was accused of serving in Osama bin Laden's security detail and imprisoned for nearly 13 years without charge in Guantanamo Bay
updated 12:38 PM EST, Sun December 14, 2014
S.E. Cupp asks: How much reality do you really want in your escapist TV fare?
updated 1:28 PM EST, Thu December 11, 2014
Rip Rapson says the city's 'Grand Bargain' saved pensions and a world class art collection by pulling varied stakeholders together, setting civic priorities and thinking outside the box
updated 6:10 PM EST, Sat December 13, 2014
Glenn Schwartz says the airing of the company's embarrassing emails might wake us up to the usefulness of talking in-person instead of electronically
updated 5:33 PM EST, Fri December 12, 2014
The computer glitch that disrupted air traffic over the U.K. on Friday was a nuisance, but not dangerous, says Les Abend
ADVERTISEMENT
ADVERTISEMENT
ADVERTISEMENT
ADVERTISEMENT